CHEN Yang,LIN Zui-qi,XU Li,et al.Effects of Different Preparation of Soymilk on the Quality of Tofu[J].Soybean Science,2011,30(05):838-842.[doi:10.11861/j.issn.1000-9841.2011.05.0838]
豆浆制备工艺对豆腐品质的影响
- Title:
- Effects of Different Preparation of Soymilk on the Quality of Tofu
- 文章编号:
- 1000-9841（2011）05-0838-05
- Keywords:
- Tofu; Preparation of soymilk; Quality; Sensory
- 分类号:
- TS201.1
- 文献标志码:
- A
- 摘要:
- 分别在实验室和工厂中试条件下利用生浆法、熟浆法、热水套浆法3种不同制浆工艺制备豆腐，对豆腐的出品率、含水量、保水性、质构与感官性状进行了分析比较。结果表明：熟浆法豆腐的出品率、含水量和保水性分别比生浆法和热水套浆法提高了12%和7%、6%和7%、13%和5%，但生浆法豆腐的硬度、黏附性等指标均高于其它2种制浆工艺；熟浆法豆腐获得较高的感官评价。不同制浆工艺豆腐各物性指标差异显著，无论是实验室还是工厂中试条件，不同制浆工艺对豆腐品质的影响基本一致。
- Abstract:
- In this research the yield,moisture content,water retention,texture and sensory properties of different tofu were compared with regard to 3 kinds of soymilk preparation methods in laboratory and pilot plant.The results showed that the yield,moisture content and water retention of tofu made by cooked slurry respectively increased by 12% and 7%,6% and 7%,13% and 5% than uncooked slurry and hot water mixed slurry.The breaking stress,adhesiveness and chewiness of tofu made by uncooked slurry were higher than the other two slurries.Tofu made by cooked slurry obtained a higher sensory evaluation.Tofu made by different preparation of soymilk were significantly different in physical properties.Effect of different preparation of soymilk on the quality of tofu had the same results basically both in laboratory and factory experiments.
参考文献/References:
[1]Toda K,Chiba K,Ono T.Effect of components extracted from okara on the physicochemical properties of soymilk and tofu texture[J].Journal of Food Science,2007,72(2):108-113. [2]韩雅珊.食品化学实验指导[M].北京:中国农业大学出版社,1992,1-2.(Han Y S.Experiment guidance of food chemistry[M].Beijing:China Agricultural University Press,1992.) [3]Fuh-J K,Nan W S,Min H L.Effect of water-to-bean ratio on the content and composition of isoflavones in tofu[J].Journal of Food Chemistry,2004,52:2277-2281. [4]Cai T D,Chang K C.Characteristics of production-scale tofu as affected by soymilk coagulation method:Propeller blade size,mixing time and coagulant concentration[J].Food Research International,1998,31:289-295. [5]孙彩玲,田纪春,张永祥.TPA质构分析模式在食品研究中的应用[J].实验科学与技术,2007,5(2):1-4.(Sun C L,Tian J C,Zhang Y X.The application of TPA texture profile analysis mode in food research[J].Experimental Science and Technology,2007,5(2):1-4.) [6]Wang H L,Swain E W,Wolek W F K,et al.Effect of soybean varieties on the yield and quality of tofu[J].Cereal Chemistry,1983,60(3):245-248. [7]钱虎君,盖钧镒.豆乳和豆腐加工过程中滤渣方法和絮凝时间对营养成分利用的影响[J].大豆科学,2001,20(1):18-21.(Qian H J,Gai J Y,Yu D Y.Effect of different filtering methods and coagulating time treatments to utilization of nutrients in soymilk and processing[J].Soybean Science,2001,20(1):18-21.) [8]张明晶,魏益民,张波,等.加工条件对豆腐质量特性的影响[J].大豆科学,2006,25(4):395-398.（Zhang M J,Wei Y M,Zhang B,et al.Effects of processing conditions on the quality of tofu-gel[J].Soybean Science,2006,25(4):395-398.） [9]Gandhi A P,Bourne M C.Effect of pressure and storage time on texture profile parameters of soybean curd(tofu)[J].Texture Studies,1988,19：137-142.
相似文献/References:
[1]谢来超,沈群,张新艳,等.基于神经网络法对原料大豆豆腐加工特性的评价[J].大豆科学,2013,32(01):93.[doi:10.3969/j.issn.1000-9841.2013.01.022]
XIE Lai-chao,SHEN Qun,ZHANG Xin-yan,et al.Evaluation on Tofu Processing Characteristics of Soybean Based on Neural Network[J].Soybean Science,2013,32(05):93.[doi:10.3969/j.issn.1000-9841.2013.01.022]
[2]沈丹萍,王小平,秦立强.大豆异黄酮摄入与卵巢癌关系的Meta分析[J].大豆科学,2013,32(06):814.[doi:10.11861/j.issn.1000-9841.2013.06.0814]
SHEN Dan-ping,WANG Xiao-ping,QIN Li-qiang.Isoflavones Intake and Risk of Ovarian Cancer:A Meta Analysis of Epidemiological Study[J].Soybean Science,2013,32(05):814.[doi:10.11861/j.issn.1000-9841.2013.06.0814]
[3]刘香英,康立宁,田志刚,等.不同凝固剂对豆腐风味的影响[J].大豆科学,2011,30(06):993.[doi:10.11861/j.issn.1000-9841.2011.06.0993]
LIU Xiang-ying,KANG Li-ning,TIAN Zhi-gang,et al.Influence of Different Coagulant on Volatile Flavor of Tofu[J].Soybean Science,2011,30(05):993.[doi:10.11861/j.issn.1000-9841.2011.06.0993]
[4]宋莲军,高晓延,胡丽娜,等.豆腐酸性凝固剂的研究[J].大豆科学,2012,31(06):1002.[doi:10.3969/j.issn.1000-9841.2012.06.031]
SONG Lian-jun,GAO Xiao-yan,HU Li-na,et al.Selection of Acid Coagulant for Tofu[J].Soybean Science,2012,31(05):1002.[doi:10.3969/j.issn.1000-9841.2012.06.031]
[5]李湘利,刘静,胡彦营,等.红香椿内酯豆腐生产工艺的研究[J].大豆科学,2010,29(06):1038.[doi:10.11861/j.issn.1000-9841.2010.06.1038]
LI Xiang-li,LIU Jing,HU Yan-ying,et al.Research on the Production Technology of Red Toona Sinensis Lactone Tofu[J].Soybean Science,2010,29(05):1038.[doi:10.11861/j.issn.1000-9841.2010.06.1038]
[6]王春娥,盖钧镒.大批量小样品豆腐与豆乳得率的定量分析技术研究[J].大豆科学,2007,26(02):223.[doi:10.3969/j.issn.1000-9841.2007.02.022]
WANG Chun-e,GAI Jun-yi.STUDY ON MEASUREMENT TECHNOLOGY OF TOFU AND SOYMILK OUTPUT FOR LARGE AMOUNT OF MINI-SPECIMEN[J].Soybean Science,2007,26(05):223.[doi:10.3969/j.issn.1000-9841.2007.02.022]
[7]冷进松,郝晓玮.乳清粉营养豆腐加工工艺研究[J].大豆科学,2015,34(03):485.[doi:10.11861/j.issn.1000-9841.2015.03.0485]
LENG Jin-song,HAO Xiao-wei.Processing Technological Study on Health Food of Whey Powder Tofu[J].Soybean Science,2015,34(05):485.[doi:10.11861/j.issn.1000-9841.2015.03.0485]
[8]盖钧镒 钱虎君 吉东风 王明军.豆乳和豆腐加工过程中营养成分利用的品种间差异[J].大豆科学,1999,18(03):199.[doi:10.11861/j.issn.1000-9841.1999.03.0199]
Cai Junyi Qian Hujun Ji Dongfeng Wang Mingjun.GENOTYPIC VARIATION OF UTILIZATION OF NUTRIENTS IN SOYMILK AND TOFU PROCESSING[J].Soybean Science,1999,18(05):199.[doi:10.11861/j.issn.1000-9841.1999.03.0199]
[9]钱虎君 盖钧镒 喻德跃.取样大小对微样品分析豆乳和豆腐产量的影响[J].大豆科学,2002,21(04):255.[doi:10.11861/j.issn.1000-9841.2002.04.0255]
Qian Hujun Gai Junyi Yu Deyue.EFFECT OF DIFFERENT SPECIMEN TO SOYMILK AND TOFUOUTPUT WITH THE MICRO -SPECIMEN ANALYSIS[J].Soybean Science,2002,21(05):255.[doi:10.11861/j.issn.1000-9841.2002.04.0255]
[10]钱虎君 盖钧镒 喻德跃.大豆豆腐性状的遗传育种研究进展[J].大豆科学,2003,22(01):59.[doi:10.11861/j.issn.1000-9841.2003.01.0059]
Qian Hujun Gai Junyi Yu Deyue.A REVIEWON SOYBEAN GENTICS AND BREEDING OF THE TOFU TRAITS[J].Soybean Science,2003,22(05):59.[doi:10.11861/j.issn.1000-9841.2003.01.0059]
备注/Memo